Hellenbrand Iron Curtain System Bedienungsanleitung

For systems manufactured after October 1997Manufactured by:HELLENBRAND, INC.404 Moravian Valley Road • PO Box 187Waunakee, Wisconsin 53597Phone: 608-8

10How To Manually RegenerateYour Water Filter At Any TimeSlowly turn the manual regeneration knob clockwise until thedrive motor starts running.The mo

11How To Set Regeneration Cycle Program1 How to set the regenerationcycle program.The regeneration cycle program on your Iron Curtain Filterhas been f

12Iron Curtain SystemIron Curtain Wiring Diagram123WHITEBLK/WHTGREENGREENBLACKWHWHITEBLK/WHTBROWNYELLOWREDBLACKWHITEBLK/WHTBROWNYELLOWREDBLACKBLACKBLA

13Iron Curtain Timer AssemblyITEM NO. NO. REQ'D. PART NO. DESCRIPTION1 ... 1 ... 49-13870 ... Timer Housing2 ...

14Iron Curtain Control Drive Assembly321079111284131412313317161819283029262524212027342315ITEM NO. NO. REQ'D. PART NO. DESCRIPTION1 ...

15Iron Curtain Aeration PumpItem PartNo. No. Description Qty.1... 74-625646 ... Screw/Head ... 42..

16Iron Curtain Aeration Pump Repair InstructionsAir pump must be removed from tank and have powersupply disconnected before proceeding. 1. Re

17IC-10 Series Control Valve AssemblyITEM NO. NO. REQ'D. PART NO. DESCRIPTION1 ... 1 ... 49-11212NP .. Nickel Valve B

181IC-12 Series Control Valve Assembly141234511109876121315121920161718ITEM NO. NO. REQ'D. PART NO. DESCRIPTION1 ... 1 ...

19Instructions for ReplacingPiston Assembly and Seal KitReplacing Piston Assembly See pages 17 and 18 for Parts Diagrams. 1. Place Iron Curtain System

2Congratulations on your purchase of one of the finest water treatment systems available today – the IronCurtain System. This patented, non-chemical f

20RemovingPower HeadRemoving Seal fromValve BodyPistonBack PlateSeal Hook to Remove SealsSealFIGURE 14FIGURE 158. Using the puller, remove the first s

21Removing Spacerfrom Valve BodyReplacing Spacer inValve BodyPlacing Seal inBrass Sleeve of StufferRemoving Stuffer from ValveBody after Inserting Sea

22IRON CURTAIN FLOW DIAGRAMSStep 1. Service PositionRaw water enters the aeration-tank inlet, flows thru the inletdiffuser, thru a head of air, downth

23Step 3. Bleeding Off theAeration SystemThe Iron Curtain Control Centerautomatically shifts the controllerinto the Aeration recharge cycle.The air bl

24Step 5. Bleeding Off Excess AirThe Iron Curtain Control Centerautomatically turns the air com-pressor pump off and allows bothvalves to remain open.

251a. Clean or replace drain line flowcontrol2a. Check for minimum specified flow andpressure requirements of filter system3a. (Generally will only pl

26Complaint Problem Cause SolutionA. Dirt lodged under seat of valveB. Faulty or defective relief valveA. This can be expected when wateris aerated un

27Winterizing Iron CurtainSystems (Optional)In certain climates where houses and/or cottages are notheated during the winter months, Iron Curtain Syst

2873-5107/03-2500IRON CURTAIN FILTER SYSTEMSLIMITED WARRANTYHellenbrand, Inc., warrants to the original consumer/purchaser against defects in material

3INSTALLATION DATADate of Installation _______________________________________ Model No.___________________________________Address of Installati

4IRON CURTAINthe way to solve this problem is to use layers of media.”The advantages of a multi-media bed are:1. Longer runs between backwash times.2.

5Operating ConditionsThe Iron Curtain System has been validated by the WQAunder their S-200 Filter Standard for the reduction/removal ofiron, manganes

6Caution: The water pressure is not to exceed 70 p.s.i.; watertemperature is not to exceed 110° F; conditioner cannot besubject to freezing conditions

7Instructions for Adding IC pHCorrection MediaSee Figures 1, 2 & 3 on page 8..1. Place Iron Curtain System on bypass. (Close inlet andoutlet valve

8Due to existing plumbing conditions, you may want to choose an alternate installation configuration.Refer to Figures 2 and 3 below for alternate inst

9How To Set Timer1 How to set days on which waterconditioner is to regenerate.Rotate the skipper wheel until the number "1" is at the redpoi